Exam (elaborations)
Refrigeration-Air Conditioning Exam Questions and Answers 2025.
- Course
- Institution
Refrigeration-Air Conditioning Exam Questions and Answers 2025.
[Show more]
Content preview
1Refrigeration-Air Conditioning Exam
Questions and Answers 2025.
1. When repairing a refrigeration system, a swaging tool set would be used to
carry out which of the following operations? - ASNWER-Swaging tools can be used
to expand an end of one tube to fit onto a tube of the same original outside
diameter.
2. In a refrigeration system that is not protected by a water failure switch, if the
cooling water to the condenser fails, what will be the result for protective
purposes? - ASNWER-the compressor will shut down by the action of the high-
pressure cutout switch
3. When the relief valve opens on a refrigeration compressor discharge line, it
discharges high-pressure refrigerant vapor to what location? - ASNWER-suction
side of the compressor
4. Which of the lettered components shown in the illustration indicates the high-
pressure cutout? Illustration GS-RA-12 - ASNWER-X
5. The rupture disc on a low-pressure centrifugal refrigeration unit is used as an
overpressure protection device and is set to relieve at 15 psig and is most likely to
lift when the compressor is idle. Where is the rupture disc located? - ASNWER-on
top of chiller evaporator shell
6. During the initial cooling down of a box temperature in a refrigeration system,
which of the devices listed is used to prevent excessive gas pressure at the
compressor suction for the purpose of prevention of overloading of the
compressor driver? - ASNWER-Crankcase pressure regulator
1
,2
7. A reheater in an air conditioning system performs what function? - ASNWER-
restores the conditioned air temperature to a comfortable level
8. What is one benefit of maintenance of proper air circulation in an air
conditioned cargo space? - ASNWER-reduced slime and mold
9. In a two stage centrifugal air conditioning system, the liquid refrigerant passes
through the condenser directly to what component? - ASNWER-economizer
10. In an air conditioning system, what is the name of the chamber where the
duct-work originates? - ASNWER-plenum chamber
2
,3
11. What is the wet bulb temperature of air if the dry bulb temperature of the air
is 90 degrees and the relative humidity is 65%? Illustration GS-RA-22 - ASNWER-80
degrees F
12. In general, the thermal bulb for a thermal expansion valve used in a
reciprocating air conditioning system is usually charged with what substance? -
ASNWER-the same refrigerant as the system
13. Heat is removed from the refrigerant circulating through the refrigeration
system, shown in the illustration, by which component? Illustration GS-RA-12 -
ASNWER-B
14. Sea water or low temperature central fresh water is typically provided to a
ship's stores refrigeration plant for what purpose? - ASNWER-condense the
refrigerant gas
15. Zinc plates commonly found in refrigeration systems and used as sacrificial
anodes are located where? - ASNWER-salt water side of the condenser
16. Vapor bubbles present in the liquid upon arrival to the thermal expansion
valve in a refrigeration system may cause erosion of the expansion valve's needle
and seat. This, in turn, could cause what condition? - ASNWER-TXV hunting
17. Moisture entering a typical refrigeration system will most likely produce what
effect? - ASNWER-freeze in the expansion valve
3
, 4
18. A small obstruction at the thermostatic expansion valve inlet will result in
which of the following conditions? - ASNWER-Lower than normal suction
pressure.
19. An obstructed expansion valve may be indicated by an incompletely cooled
evaporator and what other symptom? - ASNWER-frosting at the evaporator inlet
20. Which of the following conditions will occur if the power element of the
thermostatic expansion valve shown in the illustration loses its charge? Illustration
GS RA-07 - ASNWER-The valve will fail closed, providing no cooling capacity.
21. If the needle and seat assembly is excessively eroded, the valve cage assembly
can be replaced. In replacing the original valve cage assembly rated at 1/2 tons,
what would be the result if the replacement valve cage was oversized at 5 tons?
Illustration GS-RA-07 - ASNWER-The expansion valve would hunt excessively,
alternately starving and overfeeding the evaporator coil.
22. If the superheat value of the thermostatic expansion valve is adjusted too
high, what would be the result? - ASNWER-the suction line of the compressor will
be abnormally warm
23. If the superheat setting of a thermostatic expansion valve is set too low, what
would be the result, assuming that the system has a single evaporator? - ASNWER-
the suction line will be abnormally cold and liquid may flood back to the
compressor
24. Which of the illustrated valves is used to gain access to a hermetic system and
features a Schrader core valve which is unseated by the core depressor of hose
fitting when attached? Illustration GS-RA-69 - ASNWER-D
4
The benefits of buying summaries with Stuvia:
Guaranteed quality through customer reviews
Stuvia customers have reviewed more than 700,000 summaries. This how you know that you are buying the best documents.
Quick and easy check-out
You can quickly pay through credit card or Stuvia-credit for the summaries. There is no membership needed.
Focus on what matters
Your fellow students write the study notes themselves, which is why the documents are always reliable and up-to-date. This ensures you quickly get to the core!
Frequently asked questions
What do I get when I buy this document?
You get a PDF, available immediately after your purchase. The purchased document is accessible anytime, anywhere and indefinitely through your profile.
Satisfaction guarantee: how does it work?
Our satisfaction guarantee ensures that you always find a study document that suits you well. You fill out a form, and our customer service team takes care of the rest.
Who am I buying these notes from?
Stuvia is a marketplace, so you are not buying this document from us, but from seller TutorExpert. Stuvia facilitates payment to the seller.
Will I be stuck with a subscription?
No, you only buy these notes for $22.49. You're not tied to anything after your purchase.
Can Stuvia be trusted?
4.6 stars on Google & Trustpilot (+1000 reviews)
80796 documents were sold in the last 30 days
Founded in 2010, the go-to place to buy study notes for 14 years now